Select Vehicle From Dropdown

01E 6-speed Minimal Repair Kit for 1-2 Shift Problem (OEM) w/ OEM Collar

SKU: OEM-01E311239L-fix

$1,395.00

Details
Details
NOTE: We now offer a 01E Minimal Repair Kit with our JHM Performance Carbon Synchros for a MUCH lower price than OEM synchros while providing better performance. Please go back to the "Transmission Parts" Section of our store and look for our "01E 6-Speed Minimal Repair Kit (JHM-Performance) w/ Updated 1-2 Collar".

Fits all 01E transmissions with the EDU (B5 S4), FZY, DSY, FZV, FDP(B5 RS4), FTU, FTG and FZW trans codes

Minimal kit ONLY to patch up your trans and just fix the bad 1-2 shift collar and the 1st and 2nd gear syncrhos.

INCLUDES THE FOLLOWING OEM updated 1 and 2 synchronizer rings only - OEM synchronizer springs (2) - OEM input shaft seal - OEM case gasket - new OEM updated 1-2 shift collars - inner and outer (note: recently we have been getting both the inner and outer collar from our parts supplier. However, it's possible that we'll may only send the outer collar if our supplier switches back. This won't be an issue as the inner collar never fails, if yours is locked up just press it apart.) This is the part that causes 1st and/or 2nd gear to lock up when it fails.

OPTIONS: If you want to at least replace the 3rd and 4th gear synchros as well since they are prone to failure, we sell them individually as well. Go back to the "Transmission Parts" section and select the "01E Synchro (JHM-Performance), 3rd-4th-5th-6th Gear - EACH" product. You can then add however many extra JHM Performance Carbon Synchros to your Repair Kit that you want. Replacing these synchros, will decrease your chances later of having to take your transmission apart later for a 3rd or 4th gear synchro.

NOTE: This is the MINIMAL kit just to repair 1st and 2nd. It does not come with any other synchros for 3rd, 4th, 5th and 6th, nor does it come with output shaft seals. JH Motorsports does NOT recommend this repair since it is likely you will have to take your transmission apart again for 3rd, 4th, 5th or 6th gear synchros or have to address output shaft seal leaks later.

6TH GEAR OPTIONS: If you are looking for better fuel economy and/or a higher top speed in 6th gear, there are two options we sell. Go back to the "Transmission Parts" section and select the "01E-Higher 6th gear for better fuel economy and higher top speed". The stock 6th gear is .68 and yields about 3000rpm at 80mph. The .60 Overdrive option yields about 2650rpm at 80mph and the .56 Overdrive option yields about 2450rpm at 80mph. These gears are high quality OEM gears direct from Germany, and are not available from Audi dealers in the United States. We have many other ratios available for the other gears as well. (Allow 2 to 3 weeks for delivery on the gears, depending on current availability.) Click HERE for our 6th gear RPM vs. MPH chart

VIEW INFORMATIONAL VIDEO ABOUT THE COMMON ISSUES WITH THESE TRANSMISSIONS -->HERE

VIEW INFORMATIONAL VIDEO ABOUT THE LINKAGE ON THESE CARS -->HERE

Link to the contents of the kit and recommended tools:-->HERE
NOTE: These contents have a longer list than this kit but the tools and info are the same.


NOTE: Kits usually ship out from our location within 1 to 4 days depending on our current stock.

For shipping quotes: Please sign in or join then put the items you want in your shopping cart and proceed to checkout.


This product fits the following vehicles:
Make Model Chassis Engine
Audi RS4 B5 (1999-2001) 2.7t V6 30v
Audi A6 C5 (1998-2004) 2.7t V6 30v
Audi A4 B6 (2002-2005) 3.0l V6 30v
Audi allroad C5 (2001-2005) 2.7t V6 30v
Audi S4 B5 (1997-2002) 2.7t V6 30v
Reviews
Write Your Own Review
You're reviewing: 01E 6-speed Minimal Repair Kit for 1-2 Shift Problem (OEM) w/ OEM Collar
Off-road Use

By Purchasing any Off-Road use ONLY products from JH Motorsports, Inc. I acknowledge and understand the following disclosure. (This notice is located at the bottom of the page description of affected products on our website.)

Vehicle Code § 27156:
(b) No person shall operate or leave standing upon a highway a motor vehicle that is required to be equipped with a motor vehicle pollution control device under Part 5 (commencing with Section 43000) of Division 26 of the Health and Safety Code or any other certified motor vehicle pollution control device required by any other state law or any rule or regulation adopted pursuant to that law, or required to be equipped with a motor vehicle pollution control device pursuant to the National Emission Standards Act (42 U.S.C. Secs. 7521 to 7550, inclusive) and the standards and regulations adopted pursuant to that federal act, unless the motor vehicle is equipped with the required motor vehicle pollution control device that is correctly installed and in operating condition. No person shall disconnect, modify, or alter any such required device.
(c) No person shall install, sell, offer for sale, or advertise any device, apparatus, or mechanism intended for use with, or as a part of, a required motor vehicle pollution control device or system that alters or modifies the original design or performance of the motor vehicle pollution control device or system.

Health and Safety Code § 43000:
43001. The provisions of this part shall not apply to:
(a) Racing vehicles.

As the aforementioned code sections outline, it is against the law to operate or use a vehicle on public streets or highways with modified, altered, or disconnected motor vehicle pollution control devices. This may include but is not limited to, Evaporative Fuel Controls, Catalysts, DPF, PTOX, PCV Systems, Exhaust Gas Recirculation Systems, Oxygen Sensors, Thermostatic Air Cleaners, Air Intake Systems, Fuel Injectors, Regulators, Adjustable Cam Gears, ECU Programming, Mapping, or other Computer Modifications. Air Pumps, Air Injection, Timing, and any other Emission System Modification(s).

Purchaser acknowledges and certifies to JH Motorsports Inc., that Purchasers vehicle will only be used for racing applications or off road vehicle use only. Purchaser requests these modifications for the purpose of enhancing the vehicle for competitive Racing Applications and will not use this vehicle on public streets or highways. Purchaser agrees to indemnify JH Motorsports Inc., all employees, officers, owners, and subsidiaries for any civil or criminal liability arising out of use of Purchasers vehicle on public streets or highways as Purchaser has been duly notified of the laws and regulations regarding disconnecting, alteration, or modification of a vehicle’s pollution control devices. Purchaser understands and has been advised the driving of a vehicle on public streets or highways could result in criminal or civil penalties.

Prop 65

Warning: This product may contain a chemical known to the State of California to cause cancer, birth defects, or other reproductive harm.

Learn More: www.p65warnings.ca.gov

Q and A

Product Questions

No questions yet. Be the first to ask the question!
You may also be interested in the following product(s)