Select Vehicle From Dropdown

JHM Stage 3 Performance Clutch, DISC ONLY, for JHM C5, B5, B6, B7 240mm Clutch Kits

SKU: JHM-ClutchDisc

$399.95

Details
Details
PROUDLY MADE LOCALLY HERE IN THE USA

NOTE: This clutch disc will fit any pressure plate and flywheel setup that has a 240mm disc. This disc will fit ANY JHM Clutch and/or Flywheel Combo featuring the B7-RS4 Pressure Plate OR the JHM "R Series" pressure plate.

In typical JHM style here are some videos of some of the abuse we have put these clutch discs through on a lot of our JHM Cars:

JHM burnouts and abuse with our B6-S4:

JHM B5-S4 with JHM RS6-Rs running 10.8:

JHM B6-S4 with JHM Supercharger Kit, 11.96 at 116:

JHM B7-RS4 12.40 all motor pass and burnouts:

JHM B6-S4 12.70 all motor pass, 12.29 JHM Nitrous pass, Dyno:

SPECIFICATIONS - These JHM Stage 3 (hybrid Ceramic/Metal Backed Organic) discs are from a result of actual on car testing (video proof above) and from pressure plate clamp load testing that JHM had performed on all the available pressure plates for the B6-B7 S4 and RS4. Most of the on car testing was to find the optimal materials for the most streetability while delivering the performance any Naturally Aspirated B6-B7 S4 could dish out. The hybrid combination of materials has made the clutch hold better and handle higher heat as well while still being smooth enough for every day driving with a stock like pedal feel.


INCLUDES THE FOLLOWING
- JHM Stage 3 (hybrid Ceramic/Metal Backed Organic)

The risk with reusing a used non-resurfaced flywheel with a new clutch. In our experience with many different clutches we have tested and installed over the years we have found that when you do not replace or resurface your flywheel the new clutch disc friction material may not bed in correctly, thus causing a chatter when starting from stops. This is not always the case but can happen, JHM just wants their customers to be aware of this risk. If you are concerned about this check out our 2 different flywheel and clutch combos we sell in this section.

INSTALLATION AND TORQUE NOTES HERE

NOTE: Clutch break-in is important and must be done properly. For the Stage 3 clutches you need to drive as much city type driving as you can for the first 500 miles (each time you start from a stop or shift it aids in break in, highway mileage does not count). For Stage 4 clutches the procedure is the same but you must do this break in procedure for 750 miles. Due to Kevlar's resistance to wear it takes longer to break in. You also MUST avoid any racing activities, launching, or aggressive driving that gets the clutch too hot during this period.

For shipping quotes: Please sign in or join then put the items you want in your shopping cart and proceed to checkout.


This product fits the following vehicles:
Make Model Chassis Engine
Audi S4 B6 (2003-2005) 4.2l V8 40v
Audi S4 B7 (2005.5-2009) 4.2l V8 40v
Audi A4 B5 (1996-2001) 1.8t
Audi A4 B6 (2002-2005) 1.8t
Audi A4 B6 (2002-2005) 3.0l V6 30v
Audi A4 B7 (2005.5-2009) 2.0t FSI
Audi A6 C5 (1998-2004) 2.7t V6 30v
Audi allroad C5 (2001-2005) 2.7t V6 30v
Audi RS4 B5 (1999-2001) 2.7t V6 30v
Audi RS4 B7 (2006-2009) 4.2l V8 32v FSI
Audi S4 B5 (1997-2002) 2.7t V6 30v
Reviews
Write Your Own Review
You're reviewing: JHM Stage 3 Performance Clutch, DISC ONLY, for JHM C5, B5, B6, B7 240mm Clutch Kits
Off-road Use

By Purchasing any Off-Road use ONLY products from JH Motorsports, Inc. I acknowledge and understand the following disclosure. (This notice is located at the bottom of the page description of affected products on our website.)

Vehicle Code § 27156:
(b) No person shall operate or leave standing upon a highway a motor vehicle that is required to be equipped with a motor vehicle pollution control device under Part 5 (commencing with Section 43000) of Division 26 of the Health and Safety Code or any other certified motor vehicle pollution control device required by any other state law or any rule or regulation adopted pursuant to that law, or required to be equipped with a motor vehicle pollution control device pursuant to the National Emission Standards Act (42 U.S.C. Secs. 7521 to 7550, inclusive) and the standards and regulations adopted pursuant to that federal act, unless the motor vehicle is equipped with the required motor vehicle pollution control device that is correctly installed and in operating condition. No person shall disconnect, modify, or alter any such required device.
(c) No person shall install, sell, offer for sale, or advertise any device, apparatus, or mechanism intended for use with, or as a part of, a required motor vehicle pollution control device or system that alters or modifies the original design or performance of the motor vehicle pollution control device or system.

Health and Safety Code § 43000:
43001. The provisions of this part shall not apply to:
(a) Racing vehicles.

As the aforementioned code sections outline, it is against the law to operate or use a vehicle on public streets or highways with modified, altered, or disconnected motor vehicle pollution control devices. This may include but is not limited to, Evaporative Fuel Controls, Catalysts, DPF, PTOX, PCV Systems, Exhaust Gas Recirculation Systems, Oxygen Sensors, Thermostatic Air Cleaners, Air Intake Systems, Fuel Injectors, Regulators, Adjustable Cam Gears, ECU Programming, Mapping, or other Computer Modifications. Air Pumps, Air Injection, Timing, and any other Emission System Modification(s).

Purchaser acknowledges and certifies to JH Motorsports Inc., that Purchasers vehicle will only be used for racing applications or off road vehicle use only. Purchaser requests these modifications for the purpose of enhancing the vehicle for competitive Racing Applications and will not use this vehicle on public streets or highways. Purchaser agrees to indemnify JH Motorsports Inc., all employees, officers, owners, and subsidiaries for any civil or criminal liability arising out of use of Purchasers vehicle on public streets or highways as Purchaser has been duly notified of the laws and regulations regarding disconnecting, alteration, or modification of a vehicle’s pollution control devices. Purchaser understands and has been advised the driving of a vehicle on public streets or highways could result in criminal or civil penalties.

Prop 65

Warning: This product may contain a chemical known to the State of California to cause cancer, birth defects, or other reproductive harm.

Learn More: www.p65warnings.ca.gov

Q and A

Product Questions

No questions yet. Be the first to ask the question!
You may also be interested in the following product(s)
JHM Supercharger Kit for B8-S5 w/ 4.2L FSI V8, Stage 1 JHM Supercharger Kit for B8-S5 w/ 4.2L FSI V8, Stage 1
1 Review(s)

Select options & add to cart to view final price
From: $7,199.95

To: $8,344.95

Flywheel and Clutch Combo (LUK-OEM updated) for 04 and up B6-B7 S4 Flywheel and Clutch Combo (LUK-OEM updated) for 04 and up B6-B7 S4

Select options & add to cart to view final price
From: $1,124.95

To: $1,424.95